WP10 Engine Air Compressor
Air compressor: It consists of a motor, air compression cylinder, oil and gas separation tank, dryer, air storage tank, etc. When the motor is started, air enters through the suction port of the air compression cylinder, and the compressed air passes through the oil and gas separation tank to compress the air. The generated water is filtered, the compressed and filtered moist air is dried by a dryer, and then the dry compressed air is stored in the air tank and sent to the load. The basic principle is like this. In fact, it is very simple. After a series of treatments by an air compressor, ordinary air is sent out as dry and high-pressure air.
Air compressor model:
| 1001022848 | 1000904146 | 1000903890 | 1000889077 | 1000848276 | 1000835585 | 1000769549 | 1000406884 | 081V54100-7070 |
| 1001496994 | 1001784818 | 1002057177 | 1002300936 | 1002300936 | 1002365110 | 1002491954 | 1002491967 | 1003185665 |
|
202V54100-7131 |
1004636892 | 410800130010 | 610800130072 | 612600130063 | 5010224650 | 612600130082 | 612600130119 | 612600130125 |
| 13062016 | 13026014 | 13024590 | 13023181 | 13021188 | 1003288636 | 3509010AL51-3100 | 3509010A614-0435 | 3509010-E787 |
| 3509010-630-0828 | 3509010-614-2435 | 3509001A52D | 3509100AB46-SS1A | 3509090-A12 | 3509010C852-0105 | 3509010AM67-072N | 3509010AM55-092W | 3509010AM54-0B2005 |
| 5537212 |
3696936 4974668 |
612600130177 | 612600130173 | 612600130159 | 612600130158 | 612600130154 | 612600130147 | 612600130130 |
| 612600130616 | 612600130524 | 612600130479 | 612600130408 | 612600130376 | 612600130386 | 612660013065 | 612600130184 | 612630030276 |
| 612630030405 | 612600131110 | 612600130984 | 612600130924 | 612600130777 | 612600130775 | 100130307 | K6100-3509100A | CY4102-81D-1 |
| D5010224392 | C4930041 | AZ1560130070 | 618DA3509002A | 61800130043 | 612630030405 | |||
Uses of air compressors:
●Compressed air is used as power.
●Compressed gases are used for refrigeration and gas separation.
●Compressed gas is used in synthesis and polymerization.
●Compressed gas for hydrofinishing of oil.
●Gas delivery.
Product and packaging:
This is a double-cylinder air compressor, that is, an air compressor and an air pump.
Engine air compressor VG15600130080，Each air compressor is packed in a wooden box.
Air compressor oil leakage fault diagnosis and troubleshooting methods:
1. If the air compressor leaks oil, pay attention to observe the oil seal part, check whether the oil seal is cracked, whether the inner lip is cracked or turned over. If there is one of the above conditions, it should be replaced; check whether there are scratches and defects on the joint surface of the oil seal and the main shaft, and if there are scratches and defects, it should be replaced. Check whether the oil return is smooth. If the oil return is not smooth, the pressure of the crankcase is too high and the oil seal leaks or falls off. It is necessary to ensure that the oil return pipe has a minimum diameter, and it is not twisted or bent, and the oil return is smooth. Check the matching dimensions of the oil seal and the box, and replace those that do not meet the standards.
2. Forcibly move the spindle to check whether the neck clearance is too large. If the clearance is too large, replace the bearing bush and oil seal at the same time.
3. Check the sealing condition of the gaskets at each joint, repair or replace the gaskets; check the bolts of the oil inlet and return oil joints and the threads of the box and tighten them.
4. Check the oil leakage of the air compressor and re-adjust the tightness of the belt. It is advisable to press down 10 mm with the thumb.
5. If the air compressor leaks oil, it is necessary to check the defects in the casting or processing of the box body, and repair or replace the defective parts.
Hot Tags: wp10 engine air compressor, Chinawp10 engine air compressor manufacturers, suppliers, factory, WD618 Engine Pistons, Wd615 Engine Crankshaft, , , Air Compressor Cylinder Valve Plate
